Product ID:071, 23BR2 DEFTOIL MEDIUM WALNUT
MSDS Date:06/20/1989
FSC:8010
NIIN:00N031630
MSDS Number: BPLMB

DEFT INC

17451 VON KARMAN AVE
IRVINE, CA 92714
US

Emergency Phone: 714-470-0400

Info Phone: 714-470-0400

Cage: 33458

DEFT, INC.

IRVINE, CA 92614 US

Telephone: 949-474-0400

Cage: 33461

5

CAS: 64742-88-7

Fraction By Weight: 60%

OSHA PEL 500 PPM (MFR)

ACGIH TLV: 100 PPM (MFR)

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (C8&10

CAS: 64742-95-6

Fraction By Weight: <5%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

VOMIT. DO NOT GIVE ANYTHING BY MOUTH TO AN

RTECS: 9999999ZZ

HAVE BEEN READ/UNDERSTOOD. SMOKE IN SMOKING

RTECS: 9999999ZZ

REMOVE ALL IGNITION SOURCES (HEAT, SPARKS, FLAMES-HOT

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: VAP ARE IRRITATING TO
EYES/NOSE/ THROAT. INHAL MAY CAUSE HDCH/DFCLT BRTHG & LOSS OF
CONSCIOUSNESS. CHRONIC: PRLNG CONT WILL CAUSE DRYING & CRACKING OF
SKIN, DUE TO DEFAT ACTION. SKIN SENSIT, AS THMA/OTHER ALLERGIC
RESPONSES MAY DEVELOP. INHAL: IRRIT OF RESP TRACT & ACUTE NERV SYS
DEPRESS CHARACT BY(EFTS OF OVEREX
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:FOLLOW PROGRESSIVE STEPS: HDCH, DIZZ,
STAGGER GAIT, CONFUSN, UNCON/COMA. SKIN: CONT CAN CAUSE IRRIT. SYMP
MAY BE SWELL/RED, & RASH. EYES:LIQ, AEROSOLS/VAP ARE IRRITATING &
MAY CAUSE TEAR/RED, & SWELL ACCOMPANIED BY STINGING SENSATION.
SKIN ABSORP: PRLNG/ RPTD CONT CAN CAUSE MOD IRRIT, DRY, & DEFAT
OF(SUPP DATA
Medical Cond Aggravated by Exposure:ASTHMA AND ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA, AND DERMATITIS.

First Aid:INHAL:MOVE TO AN AREA FREE FROM RISK OF FURTHER EXPOS.
RESTORE BRTHG. ASTHMATIC TYPE SYMP MAY DEVELOP & MAY BE
IMMED/DELAYED BY SEVERAL HRS. OBTAIN MED ATTN. SKIN:REMOVE CONTAMD
CLTHG. WASH AFFECTED A REAS THORO W/SOAP/H2O. WASH CONTAMD CLTHG
THORO BEFORE REUSE. EYES: FLUSH W/CLEAN LUKEWARM H2O (LOW PRESS)
FOR @ LST 15 MIN, OCCAS LIFTING LIDS. OBTAIN MED ATTN. INGEST: DO
NOT INDUCE (ING 3)

Flash Point Method:TCC
Flash Point:105F,41C
Lower Limits:1%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER MAY BE USED TO COOL CLSD CONTR TO PREVENT PRESSURE BUILD-UP,
AUTOIGNIT OR EXPLOSION.
Unusual Fire/Explosion Hazard:KEEP CONTR TIGHTLY CLSD. ISOLATE FROM
HEAT/ SPARKS, ELEC EQUIP & OPEN FLAMES. CLSD CONTR MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATN TO HOT SURF(SUPP DATA

Spill Release Procedures:EVACUATE ALL NON-ESSNTL PERS. REMOVE ALL
SOURCES OF IGNIT (FLAME, SPARK SOURCES, HOT SURF). VENT AREA.
CONTAIN & REMOVE WITH INERT ABSORB & NON-SPARKING TOOLS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN BLDGS DESIGNED TO COMPLY
W/OSHA 1910.106. AVOID STORING NEAR HIGH TEMP, FIRE, OPEN FLAMES, &
SPARK SOURCES. STORE IN TIGHTLY CLSD CONTR.
Other Precautions:STORE IN WELL VENTD AREAS. KEEP CONTR TIGHT & UPRIGHT
TO PVNT LEAKEAGE. PVNT PRLNG BRTHG OF VAP/SPRAY MISTS. PRLNG
OVEREXP MAY CAUSE AN ALLERGIC RXN. AVOID CONT W/SKIN/EYES. DO NOT
TAKE INTERNALLY. DO NOT HNDLE UNTIL MFR SFTY PREC (ING 4)

Respiratory Protection:NIOSH/MSHA APPRVD RESP THAT IS RECOM FOR USE IN
AN ORG VAP ENVIRON (AIR PURIFYING/FRESH AIR SUPPLIED) IS NEC.
OBSERVE OSHA REGS FOR RESP USE. VENTILATION SHOULD BE PROVIDED TO
KEEP EXPOSURE LEVELS BEL OW OSHA PERMISSIBLE LIMITS.
Ventilation:EXHAUST VENT SUFFICIENT TO KEEP AIRBORNE CONC OF SOLV VAP/
MISTS BELOW THEIR RESPECTIVE TLV'S MUST BE UTILIZED. (ING 5)
Protective Gloves:NEOPRENE, RUBBER, POLYETHYLENE.
Eye Protection:CHEM WORK GOG OR FULL LNGTH FSHLD.
Other Protective Equipment:USE LONG SLEEVE AND LONG LEG CLOTHING.
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
WASHROOM.
Supplemental Safety and Health
EXPLO HAZ: REQ SPECIAL PREC. DURING EMER CNDTNS OVEREXP TO DECOMP PROD
MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. EFTS OF
OVEREXP: SKIN WHICH CAN CAUSE SKIN TO CRACK. INGEST: CAN RSLT IN
IRRI T & POSS CORR ACTION IN MOUTH, STOM TISSUE & DIGESTIVE TRACT.
VOMIT MAY CAUSE ASPIR OF SOLV, RSLTG IN CHEM PNEUMIT.

HCC:F4
Boiling Pt:B.P. Text:306F,152C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.9
Evaporation Rate & Reference:0.1(N-BUTYL ACETATE)
Appearance and Odor:BROWN LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:64.5

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, OR OPEN FLAMES.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CO, CO2, AND
NOX.

Waste Disposal Methods:WASTE MUST BE DISPOSED OF I/A/W FED, ST, & LOC
ENVIRONMENTAL CTL REGS. EMPTY CONTR MUST BE HANDLED W/CARE, DUE TO
PROD RESIDUE & FLAMMABLE VAPOR. DO NOT INCINERATE CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.